The 2002 Saab 9-5 is a wagon that came with a choice of 2.3L 4-cyl and 3.0L 6-cyl engines. At 24 years old, many are reaching the point where repairs cost more than the car is worth. Running or not, we'll make you an offer and tow it away for free.
| Body style | Midsize Cars, Midsize Station Wagons |
|---|---|
| Engines | 2.3L 4-cyl, 3.0L 6-cyl (turbocharged versions available) |
| Transmissions | Automatic 5-spd, Manual 5-spd |
| Drive | Front-Wheel Drive |
| Fuel | Premium Gasoline, Regular Gasoline |
| Fuel economy | 16–19 city / 24–28 highway / 19–22 combined MPG |
| EPA annual fuel cost | $3,050–$4,350 a year (EPA estimate at current fuel prices, 15,000 miles) |
| Tailpipe CO₂ | 404–468 grams per mile |
| Versions tested by EPA | 10 configurations: 9-5, 9-5 Wagon |
| Age | 24 years |
Specs, fuel cost and emissions from the EPA's fueleconomy.gov data. Your car's exact equipment may differ.
NHTSA lists 6 safety recalls covering the 2002 Saab 9-5. Open recalls don't stop you from selling or junking the car, but check your VIN at nhtsa.gov/recalls to see which apply to yours.
Saab is recalling 57,389 my 2002-2008 9-5 series vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 201, "occupant protection in interior impact." during compliance testing, one of the upper interior occupant protection test points exceeded the standard's requirements.
Risk: In the event of a vehicle crash, personal injury to occupants may occur.
On certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production.
Risk: Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire.
Certain passenger vehicles equipped with b308 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads.
Risk: Overheating of the igbt occurs most often at engine start-up, but it may also occur while the engine is running. Engine stalling may occur, which could result in a crash.
Certain passenger vehicles equipped with b205/b235 4-cylinder gasoline engines and b308 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads.
Risk: Overheating of the igbt occurs most often at engine start-up, but it may also occur while the engine is running. Engine stalling may occur, which could result in a crash.
On certain passenger vehicles, if an owner changes their wheels/tires between summer and winter using a steel wheel in the winter and an alloy wheel in the summer, it is possible for rust and contamination to build up on the wheel hub during the steel wheel usage. If this occurs and the contamination is not removed, it is possible…
Risk: These fractures would result in wheel bolt breakage, allowing the wheel to detach from the wheel hub, increasing the risk of a crash.
The steering knuckle castings on certain passenger vehicles may have been contaminated during the casting process.
Risk: These knuckles can break, resulting in possible loss of steering control.
Owners have filed 65 complaints about the 2002 Saab 9-5 with NHTSA. 2 reports involved a crash and 5 reports involved a fire. Owners reported 2 injuries.
Complaints are reports from owners and aren't verified by NHTSA. One complaint can list several components. Mileage is the median odometer reading owners reported for that component.
Manufacturers have filed 63 technical service bulletins and communications with NHTSA covering the 2002 Saab 9-5. These are repair instructions for known issues, not recalls.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identif
This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended c
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
Source: NHTSA manufacturer communications (technical service bulletins).
NHTSA opened 1 defect investigation covering the 2002 Saab 9-5.
Engine stall/ engine compartment fires
Odi opened pe05-017 based on 35 reports of alleged engine stalling due to the failure of the idm cassette on the subject vehicles.all complainants reported that the engine shut down suddenly without warning and most reported that the vehicle would not restart.in 3 incidents, the complainants reported smoke and/or fire
It depends on its condition, whether major parts like the engine, transmission and catalytic converter are still there, and current scrap and parts prices where you live. Its parts make up much of its value. Enter your ZIP code above for a free offer on your specific car.
Yes. We buy 2002 9-5s that don't start, were in an accident, failed inspection or have a blown engine or transmission. Towing is always free.
Yes. Open recalls don't prevent a junk sale. NHTSA lists 6 recalls for the 2002 Saab 9-5; you can check whether any are still open on yours with the VIN lookup at nhtsa.gov/recalls.
Usually the title and a photo ID. Rules differ by state, including what to do with your plates and whether to file a notice of sale. Check our state-by-state car title guides for the official forms.
Data retrieved October 2026.
Get a free offer in minutes. Towing is always free and you get paid at pickup.