The 2002 Ford Windstar is a minivan that came with a 3.8L 6-cyl engine. At 24 years old, many are reaching the point where repairs cost more than the car is worth. Running or not, we'll make you an offer and tow it away for free.
| Body style | Minivan - 2WD |
|---|---|
| Engines | 3.8L 6-cyl |
| Transmissions | Automatic 4-spd |
| Drive | Front-Wheel Drive |
| Fuel | Regular Gasoline |
| Fuel economy | 16 city / 21 highway / 18 combined MPG |
| EPA annual fuel cost | $3,700 a year (EPA estimate at current fuel prices, 15,000 miles) |
| Tailpipe CO₂ | 494 grams per mile |
| Versions tested by EPA | 2 configurations: Windstar FWD Cargo Van, Windstar FWD Wagon |
| Age | 24 years |
Specs, fuel cost and emissions from the EPA's fueleconomy.gov data. Your car's exact equipment may differ.
NHTSA lists 8 safety recalls covering the 2002 Ford Windstar. Open recalls don't stop you from selling or junking the car, but check your VIN at nhtsa.gov/recalls to see which apply to yours.
Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations…
Risk: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Ford is recalling certain model year 1998-2003 Windstar vehicles manufactured from september 1, 1997, through july 3, 2003, and currently registered or originally sold in virginia. Over time, corrosion can weaken the rear axle making it susceptible to torsional stress. Corrosion and stress can lead to cracks which, if undetected, can…
Risk: A fractured axle can affect vehicle handling and increase the risk of a crash.
Ford is recalling certain model year 1999-2003 Windstar vehicles originally sold in or currently registered in the state of virginia. Corrosion-related fractures of the front lower control arm rear attaching brackets and body mount attachments may occur.
Risk: A separation of a front lower control arm rear attaching bracket may result in a lower control arm separation. A separation of both front subframe rear body mounts may result in separation of the steering intermediate shaft. Either conditio
Ford is recalling certain model year 1998-2003 Windstar vehicles manufactured from september 1, 1997, through july 3, 2003, registered in puerto rico. Due to increased stresses caused by high cycles of torsional loading, specific to this market, the rear axle can crack.
Risk: A fractured axle may result in a loss of vehicle control, increasing the risk of a crash.
Ford is recalling certain model year 1999-2003 Windstar vehicles originally sold in or currently registered in the states of connecticut, delaware, the district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode…
Risk: This could result in reduced steering control increasing the risk of a crash.
Ford is recalling certain model year 1998-2003 Windstar vehicles manufactured from september 1, 1997 through february 28, 2003 and currently registered or originally sold in connecticut, delaware, district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new…
Risk: A fractured axle can affect vehicle handling and increase the risk of a crash.
Ford is recalling model years 1995-2003 Windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control…
Risk: A vehicle fire could occur with or without the engine running.
Certain minivans fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." during testing, a third row bench floor-to-seat latch released before the strength requirement was met. Identical latches are used in the second row of seats.
Risk: If the latches on th4e second or third row seats of the vehicle release in a crash, the potential for occupant injury is increased.
Owners have filed 1,353 complaints about the 2002 Ford Windstar with NHTSA. 45 reports involved a crash and 48 reports involved a fire. Owners reported 53 injuries.
Complaints are reports from owners and aren't verified by NHTSA. One complaint can list several components. Mileage is the median odometer reading owners reported for that component.
Manufacturers have filed 119 technical service bulletins and communications with NHTSA covering the 2002 Ford Windstar. These are repair instructions for known issues, not recalls.
For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe
For 1998-2003 Windstar vehicles Safety Recall 10S13 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the rear axle cou
Safety recall 10S13 - Rear axle corrosion - requests for recall service action
Safety recall 11s16 - LCA rear attaching flanges or rear subframe body mount corrosion - requests for recall service action
Source: NHTSA manufacturer communications (technical service bulletins).
NHTSA opened 6 defect investigations covering the 2002 Ford Windstar.
Front Subframe Corrosion Failures
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the
Front Subframe Corrosion Failures
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in
Rear Axle Cracking
In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September
Engine compartment fires
Ea08-021 is closed with Ford's actions in recall 09v-399 recalling approximately 4.5 million vehicles equipped with texas instruments speed control deactivation switches (scds).with this recall Ford has now recalled all of the approximate 16 million Ford model vehicles that were manufactured from my 1992 through 2003 w
Engine compartment fires
Odi has received 134 consumer complaints, 285 manufacturer complaints, and 137 manufacturer warranty claims alleging incidents of engine compartment fire in model year (my) 1995 thru 2003 Ford Windstar vehicles.two of the odi complaints allege the fires caused structural damage to the complainant's home.of the 134 odi
Power sliding door opening
The subject vehicles are equipped with single or dual power sliding doors (psd).approximately 111,000 vehicles have dual power sliding doors.the psd is opened by any of 5 methods, the inside or outside manual door handle, the key fob, the overhead console switch and the b-pillar switch.the door may be opened only under
‹ Sell a 2001 Windstar · Sell a 2003 Windstar › · All Ford Windstar years
It depends on its condition, whether major parts like the engine, transmission and catalytic converter are still there, and current scrap and parts prices where you live. As a heavier vehicle, its scrap weight adds to the offer. Enter your ZIP code above for a free offer on your specific car.
Yes. We buy 2002 Windstars that don't start, were in an accident, failed inspection or have a blown engine or transmission. Towing is always free.
Yes. Open recalls don't prevent a junk sale. NHTSA lists 8 recalls for the 2002 Ford Windstar; you can check whether any are still open on yours with the VIN lookup at nhtsa.gov/recalls.
Usually the title and a photo ID. Rules differ by state, including what to do with your plates and whether to file a notice of sale. Check our state-by-state car title guides for the official forms.
Data retrieved October 2026.
Get a free offer in minutes. Towing is always free and you get paid at pickup.