NHTSA opened 10 defect investigations covering the 2007 Jeep Wrangler.
Air BagsEA21002 · opened Sep 2021, open
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to
Air BagsEA15007 · opened Dec 2015, closed Jul 2016Led to recall 16V288000
Air Bag Clockspring Wiring Failure
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This re
Air BagsPE15025 · opened Jun 2015, closed Dec 2015
Air Bag Clockspring Wiring Failure
In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the air bag warning light
Electrical SystemDP14004 · opened Sep 2014, closed Jul 2015
Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007
Air BagsPE11019 · opened May 2011, closed Nov 2011Led to recall 11V528000
Airbag Clockspring Failure
In its July 29, 2011 response to ODI's May 27, 2011 information request letter, Chrysler provided 153 MY 2007-2008 owner reports, additional to the 28 ODI Vehicle Owner Questionnaires (VOQs), which related to the illumination of the air bag light (ABL) due to a faulty clockspring (CS) wiring circuit.The right hand driv
Unknown or OtherAQ10001 · opened Nov 2010, closed Dec 2015
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-rela
Fuel System, GasolinePE10032 · opened Aug 2010, closed Feb 2011
Fuel Spill During Refueling
ODI found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.Although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previ
Power TrainPE09037 · opened Aug 2009, closed Nov 2009Led to recall 09V436000
Transmission overheating / fire
In a letter dated november 3, 2009, chrysler group llc (chrysler), notified NHTSA that it will conduct a safety recall of approximately 161,000 model year (my) 2007 and 2008 Jeep Wrangler vehicles built with automatic transmissions.chrysler stated that these vehicles were not equipped with a transmission fluid temperat
EquipmentEQ09006 · opened Jul 2009, closed Aug 2009
Tow bar assembly failure
The defective tow bar assemblies involved in this recall were supplied to chrysler for use on some of its Jeep Wrangler vehicles.the purpose of this investigation was to identify any additional purchasers of identical or substantially similar defective assemblies and to initiate additional defect reporting and safety r
Electrical SystemPE07027 · opened May 2007, closed Aug 2007Led to recall 07V291000
Engine stalling & electric power loss
On july 3, 2007, daimlerchrysler corporation (dcc) submitted a defect information report to NHTSA describing a defect that could result in engine stall while driving in approximately 80,894 model year (my) 2007 Jeep Wrangler and dodge nitro vehicles manufactured between january 30, 2006 and january 22, 2007 (NHTSA reca