The 1995 Ford Aerostar is a van that came with a choice of 3.0L 6-cyl and 4.0L 6-cyl engines. At 31 years old, many are reaching the point where repairs cost more than the car is worth. Running or not, we'll make you an offer and tow it away for free.
| Body style | Vans |
|---|---|
| Engines | 3.0L 6-cyl, 4.0L 6-cyl |
| Transmissions | Automatic 4-spd |
| Drive | Rear-Wheel Drive, 4-Wheel or All-Wheel Drive |
| Fuel | Regular Gasoline |
| Fuel economy | 14–16 city / 18–22 highway / 15–18 combined MPG |
| EPA annual fuel cost | $3,700–$4,450 a year (EPA estimate at current fuel prices, 15,000 miles) |
| Tailpipe CO₂ | 494–592 grams per mile |
| Versions tested by EPA | 4 configurations: Aerostar Van, Aerostar Wagon AWD, Aerostar Wagon |
| Age | 31 years |
Specs, fuel cost and emissions from the EPA's fueleconomy.gov data. Your car's exact equipment may differ.
NHTSA lists 5 safety recalls covering the 1995 Ford Aerostar. Open recalls don't stop you from selling or junking the car, but check your VIN at nhtsa.gov/recalls to see which apply to yours.
Vehicle description: mini vans. Heat generation in the wiring harness to the fuel pump/sender assembly can cause an electrical short. The vehicle could experience a loss of power and become immobilized and the fuel gauge may be erratic.
Risk: Heat damage, including melting or charring of the fuel pump and sender assembly wire harness and associated wiring harnesses can also result. The short circuit could also have the potential for a vehicle fire.
Vehicle description: mini vans. These vehicles were produced with a higher than specified electrical load through the accessory power feed circuit. The potential for contact between the b2 (battery), a2 (accessory), and p1 (proof) circuits can occur, creating a short circuit, allowing current to flow through the ground wire.
Risk: This can cause over heating and the potential for a vehicle fire.
Vehicle description: all wheel drive passenger minivans. These vehicles can develop powertrain bending resonance or transfer case output shaft bushing displacement. The powertrain bending resonance or the output shaft bushing displacement can result in structural failure of the transmission and/or transfer case. Fluid explusion…
Risk: This condition can cause a loss of vehicle control, and, if the expelled fluid contacts the exhaust system, a vehicle fire could occur.
The certification label on these vehicles have incorrect rear tire sizes listed. P215/70r14sl should be p215/75r14sl. This does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Risk: Consequence of non-compliance: the incorrectly sized rear tire would not have sufficient load capacity for the vehicle's specified gross axle weight rating, increasing the potential for premature tire failure.
The spare tire supplied with the vehicle can contact the brake lines on the rear axle if it is mounted in the underbody spare tire carrier. Such contact could result in fracture of a rear brake line.
Risk: This can result in reduced vehicle brake capability.
Owners have filed 157 complaints about the 1995 Ford Aerostar with NHTSA. 16 reports involved a crash and 19 reports involved a fire. Owners reported 19 injuries.
Complaints are reports from owners and aren't verified by NHTSA. One complaint can list several components. Mileage is the median odometer reading owners reported for that component.
Manufacturers have filed 82 technical service bulletins and communications with NHTSA covering the 1995 Ford Aerostar. These are repair instructions for known issues, not recalls.
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic troubl
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Source: NHTSA manufacturer communications (technical service bulletins).
NHTSA opened 3 defect investigations covering the 1995 Ford Aerostar.
Transfer cases and rear drive shaft
There is no summary currently available
Transfer cases and rear driveshaft
There is no summary currently available
Fuel sender assembly fires
There is no summary currently available
It depends on its condition, whether major parts like the engine, transmission and catalytic converter are still there, and current scrap and parts prices where you live. As a heavier vehicle, its scrap weight adds to the offer. Enter your ZIP code above for a free offer on your specific car.
Yes. We buy 1995 Aerostars that don't start, were in an accident, failed inspection or have a blown engine or transmission. Towing is always free.
Yes. Open recalls don't prevent a junk sale. NHTSA lists 5 recalls for the 1995 Ford Aerostar; you can check whether any are still open on yours with the VIN lookup at nhtsa.gov/recalls.
Usually the title and a photo ID. Rules differ by state, including what to do with your plates and whether to file a notice of sale. Check our state-by-state car title guides for the official forms.
Data retrieved October 2026.
Get a free offer in minutes. Towing is always free and you get paid at pickup.